Product ID:SHELL SOL 71,83196
MSDS Date:06/12/1989
FSC:6850
NIIN:00D007399
MSDS Number: BTTPQ

Emergency Phone: 713-473-9461/800-424-9300(CHEMTREC)

Info Phone: 713-241-4819

Preparer: G. A. VAN GELDER

Cage: 54527

Telephone: 706-863-5529

Cage: 0Y625

NAPHTHA, HEAVY ALKYLATE

CAS: 64741-65-7

Fraction By Weight: 100%

OSHA PEL 5 MG/M3 AS OIL MISTS

ACGIH TLV: 5 MG/M3 AS OIL MISTS

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:SKIN, RESPIRATORY TRACT,
CNS. ACUTE- NONIRRITATING TO EYES. PROLONGED/REPEATED SKIN CONTACT
MAY CAUSE DRYING, DEFATTING, IRRITATION & DERMATITIS. INHALATION
MAY CAUSE CNS DEPRESSION. CAN BE HARMFUL IF ASPIRATED. INGESTION
MAYCAUSE VOMITING. CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN, RESPIRATORY AND GASTROINTESTINAL TRACTS
IRRITATION, DRYING & FLAKING OF SKIN, HEADACHE, DIZZINESS, LOSS OF
COORDINATION, ABDOMINAL PAIN, NAUSEA, VOMITING. IN EXTREME CASES,
UNCONSCIOUSNESS AND D EATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE AND SKIN DISEASES
MAY BE AGGRAVATED.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION:REMOVE TO
FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR
15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER.
INGESTION:D O NOT INDUCE VOMITING. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID
INTO THE LUNGS. GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:125F,52C
Lower Limits:1
Upper Limits:7
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE-EXPOSED CONTAINERS
WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND MAY TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT MATERIAL SUCH AS SAND. PLACE IN CONTAINER
FOR DISPOSAL. PREVENT LIQU ID FROM ENTERING SEWERS, WATERWAYS OR
LOW AREAS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED AREA
AWAY FROM SOURCES OF IGNITION & OXIDIZERS. KEEP CONTAINER CLOSED.
BOND & GROUND TRANSFER CONTAINERS & EQUIPMENT.
Other Precautions:ENFORCE "NOT SMOKING" RULES IN STORAGE AREAS. USE
EXPLOSION-PROOF EQUIPMENT. CLEAN CONTAMINATED EQUIPMENT THOROUGHLY
BEFORE STARTING ANY REPAIR WORK. AVOID CONTACT WITH EYES AND SKIN.
AVOID BREATHING VAPORS. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:IF WORKING IN CONFINED AREAS, IF EXCESSIVE
MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES EXCEED RECOMMENDED
PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR NIOSH-APPROVED RESPIRATORY
PROTECTION (REFER TO 29 CFR 1910.134).
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW PEL(S).
Protective Gloves:NITRILES RECOMMENDED
Eye Protection:SAFETY GLASSES/FACE SHIELD RECOMMENDED
Other Protective Equipment:IF EXCESSIVE SPLASHING IS EXPECTED, USE A
RUBBER APRON AND FACE SHIELD. PROVIDE EYEWASH STATION AND EMERGENCY
SHOWERS.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
DIFFERENT FORMULA.

HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:255F - 295F
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Vapor Pres:<5 @ 100F
Vapor Density:5.3
Spec Gravity:0.76
Viscosity:NOT KNOWN
Evaporation Rate & Reference:0.1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT COLORED LIQUID, HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAMES, SPARKS, OTHER
SOURCES OF IGNITION
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE AND UNIDENTIFIED ORGANIC COMPOUNDS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. ALL RESPONSE ACTIVITES MUST BE COMPLY WITH
HAZPOWER (29 CFR 1910.120).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.